THE CONDENSATION OF SOME TERTIARY DIMETHYL AMYL CAHBINOLS HITH PHENOL IS THE PRESENCE OF ALUMINUM CHLORIDE A DISSERTATION Submitted to the Faculty of MICHIGAN STATE COLLEGE of Agriculture and Applied Science In partial fulfillment of the Requirements for the degree of Doctor of Philosophy by Ralph Lawrence Guile 1958 ProQuest Number: 10008320 All rights reserved INFORMATION TO ALL USERS The quality of this reproduction is dependent upon the quality of the copy submitted. In the unlikely event that the author did not send a complete manuscript and there are missing pages, these will be noted. Also, if material had to be removed, a note will indicate the deletion. uest ProQuest 10008320 Published by ProQuest LLC (2016). Copyright of the Dissertation is held by the Author. All rights reserved. This work is protected against unauthorized copying under Title 17, United States Code Microform Edition © ProQuest LLC. ProQuest LLC. 789 East Eisenhower Parkway P.O. Box 1346 Ann Arbor, Ml 4 8 1 0 6 - 1346 ACMOmLjjGMENT To Dr* R* C* Huston* the writer wishes to acknowledge his appreciation for the guidance and helpful suggestions which have made possible com­ pletion of this work* 331592 Contents Page Introduction-------------- 1 Historical---------------- £ Theoretical----- 7 Experimental > ------- - - Materials General - - - --------- - - 15 15 Alcohols 2-methyl heptanol-2 --- 16 Z, 5-dimethyl hexanol-2 ----- £* 4-dimethyl hexanol-£ ---------- 18 -------- 19 Z, 5-dimethyl hexanol-2 - - - 18 £-aethyl-5-ethyl pentanol-2-------- 19 2, 4* 4-trimethyl pentanol-2 £0 ------- Zf 5, 4-trimethyl pentanol-2------- 21 2, 5, 5-trimethyl pentanol-2 24 Condensations with Phenol Derivatives --- ---------------------- --- Proof of Structure £5 28 ----------- ----------- .— £9 Alkyl Benzenes---------------- 29 Nitration of Alkyl Benzenes---------------- 55 Oxidation of p-nitro Alkyl Benzenes --------- 55 Reduction of p-nitro Alkyl Benzenes - ---- 55 Di&zotizatioa of p-amino Alkyl Benzenes------ 54 Isolation of Phenol and Derivatives--------- 55 Matelson Synthesis of £, 4, 4-trimethyl-----2-p~hydroxyphenyl pentane - 55 Contents 1 Introduction As a contribution from this laboratory in 1956 Huston and Hsieh (1) reported the condensation of tertiary butyl, tertiary amyl, and the tjhree possible tertiary hexyl alcohols with phenol in the presence of aluminum chloride. In 1937 Huston and Hedrick (2) published results on the condensation of the tertiary heptyl alcohols with phenol using aluminum chloride as the condensing agent* Extension of this work to the tertiary octyl alcohols by Huston and Anderson (5) covered the action of methyl ethyl n-butyl and methyl ethyl tertiary butyl carbinol with phenol under the same conditions. To continue further investigation in tills field the dimethyl terti­ ary octyl alcohols were prepared and condensed with phenol in the presence of aluminum chloride. 2 Historical Preparation of the alkyl phenols to which class the principal pro­ ducts described in this thesis belong is accomplished by three general methods* First the direct alkylation of phenols using alkyl halides, acyl halides, alcohols and alkenes in the presence of various catalysts. Second the replacement of a variety of groups by a hydroxyl in alkyl benzene derivatives* And third by rearrangement of the alkyl phenyl ethers. Primary synthesis of all alkyl phenols reported herein is by the first general method and synthesis for proof of structure by the second. Since this work is concerned with the use of alcohols as alkylating agents under the catalytic influence of aluminum chloride only those papers dealing with condensations of alcohols and benzene nuclei in the presence of aluminum chloride will be included in this review. two facts should be mentioned in passing. However, First that as early as 1884 Auer (4) reported condensation between alcohols and phenols using as a catalyst a mixture of zinc and zinc chloride and second that from that time to the present alcohols and phenols have been condensed under the influence of a great variety of catalysts some of which are phosphoric acid, zinc chloride, magnesium chloride, alkali bisulfates, concentrated sulfuric acid, and perchloric acid. In 1897 Nef (5) mentioned the formation of diphenyl methane from benzyl alcohol and benzene in the presence of aluminum chloride. Re­ peating this work Huston and Friedmann (6) reported this reaction to give a 50 percent yield of diphenyl methane. A little later Huston 5 and Friedmann (7) continuing their previous work condensed successfully mixed aliphatic aromatic secondary alcohols and true aromatic secondary alcohols with benzene. In 19E4 Huston (8) extended this reaction of benzy1 alcohol using phenol, anisole, and phenetole in a similar manner to benzene* He re­ ported yields of the alkylated products as 45, 45 and 50 percent re­ spectively* Huston and Sager (9) 1916 attempted to condense various primary alcohols with benzene* negative results were obtained for methyl, ethyl, propyl, iaopi'opyl, n-butyl, isobutyl, isoamyl, phenyl ethyl and phenyl propyl alcohols. However, allyl alcohol gave a 16 per­ cent yield of a condensed product — allyl benzene. Huston and Hewmann (ID) followed this work by condensation of allyl alcohol and phenol. This led to the conclusion that only those alcohols in which the alpha carbon atom was a member of a benzene ring or was double bonded would condense under the action of aluminum chloride. Later Huston, Lewis and Grotemut (11) reported condensation between phenol and benzhydrol, methyl phenyl earbinol and ethyl phenyl carbinol. Benzhydrol giving a much larger yield of alkylated product than benzyl alcohol they stated that here was additional evidence of the effect of unsaturation of the alpha carbon atom on condensation for both the alpha carbon atoms in benzhydrol are members of an aromatic unsaturated benzene ring. Huston and Davis (12) found that the tertiary alcohol triphenyl earbinol reacted with benzene to give triphenyl methane and not tetraphenyl methane. The reaction between triphenyl earbinol and phenol has not been reported. 4 Other papers by Huston and co-workers (13) condensing benzyl or halogenated benzyl alcohols with phenol or halogenated phenols, ereeols or halogenated eresols followed* Mono and di substituted derivatives were the products* Further to investigate the effect of unsaturation of the alpha atoa on condensation Huston and Goodemoot (14) compared the reactivity of cyclohexyl, cyclopentyl, and cyclobutyl earbinols with, benzene* They showed a progressive increase in activity as the number of carbon atoms of the ring was reduced from six to four. Work with various di&ryl-alfcyl and dlalkyl-aryl earbinols by Huston and Wilsey (15), Huston and Hradel (16), and Huston and MacGomber (17) showed that they did not condense but dehydration of the alcohol occurred* All these experiments indicated that uasaturation of the alpha carbon atom, whether it was double bonded or a member of the benzene ring favored condensation reactions of aliphatic and aromatic alcohols with aromatic hydrocarbons and phenols in the presence of aluminum chloride. With the work of Huston and Hsieh (1) the field of condensation reactions of saturated aliphatic alcohols with phenol mid with benzene in the presence of aluminum chloride was discovered* In reacting iso­ propyl alcohol with benzene they obtained a fair yield of eumene (9) end following this lead using simple aliphatic primary, secondary, and terti­ ary alcohols discovered that primary alcohols did not condense with either phenol or benzene, secondary alcohols condensed with benzene (or Its homologues) and tertiary alcohols with phenol under the influ­ ence of aluminum chloride as a catalyst. Huston and Fox (18) using the 5 simple tertiary alcohols already condensed with phenol by Hsieh namely tertiary butyl, amyl and hexyl alcohols found that they condensed also with benzene, Tzukervanik (19) reported the condensation of some simple secondary and tertiary alcohols with benzene and toluene obtain­ ing results similar to those of Huston and Hsieh and Huston and Fox but explained them by a different mechanism* Since tertiary aliphatic alcohols condensed readily with both benzene and phenol an extension of this work to higher homologues of that type of compound seemed logical. Hence Huston and Binder (20) con­ densed the tertiary heptyl alcohols with benzene and Huston and Hedrick (2) condensed these same alcohols with phenol. Soon afterwards work was started in this laboratory upon the con­ densation of the tertiary octyl alcohols with phenol and benzene. Huston and Sculati (21) condensed tertiary dimethyl n-amyl, isoamyl, active amyl and secondary amyl carbinols with benzene. Huston and Anderson (5) in­ vestigated the reaction between methyl ethyl n-butyl and methyl ethyl tertiary butyl earbinol and phenol, Huston and Breining (22) described the condensation of diethyl a-propyl and diethyl isopropyl carbinols with benzene. This present work is a continuation of the investigation on the con­ densation of tertiary aliphatic octyl alcohols under the influence of aluminum chloride with phenols and benzene. In specific it deals pri­ marily with the condensation between phenol and the various dimethyl amyl carbinols* The only one of the substituted phenols prepared as principal pro­ ducts of this reaction and reported herein that has been,to the writer*a 6 knowledge, prepared end identified in the literature is <, 4, 4-tricethyl 2—p-hydroxyphenyl methane* It is the subject of a patent by Hester (23) who prepared It from phenol and diisohutylene under the action of HgSO^. It was also prepared and reported by 8 atsison (24)* 7 Theoretical In all cases of Ganderssatlone between alcohols and aromatic hydro-* carbons in the presence of aluminum chloride it has been shown by Huston and eo-workers that the alpha carbon atom of the alcohol must fee under strain such that the hydroxyl group is activated. This activation is present where the bond between carbon and the oxygen of the hydroxyl is relatively unstable* thus beasyl and allyl alcohols both of which con­ dense readily can fee represented % the following formula* it n **' ** C6BSl”= pj3iO*H i. it H«c !c s ^ cV * o »H 8 the electron pair (a) forming the bond between Q and the 0 of the hydroxyl is attracted strongly by both the -0H and the G atom resulting ** * in a bond such as found in a molecule of chlorine s Cl .* t 01 ■*. s which is unstable and hence reactive. When we Consider various primary * secondary and tertiary alcohols the existant conditions may be represented as follows. B JUC-*5 OsH *• <$ •• S H B R SjC-^j 0»H-------- UtC---VoiH •• <$.. .. (£,*■ E Relatively then the electron pair (b) is closer to the hydroxyl group in tertiary alcohols than in secondary or primary and closer to the hydroxyl in secondary alcohols than in primary. In tertiary alcohols the bond between G and 0 approaches ©ore nearly the type of bond in a *# molecule of hydrogen chloride Ii : Cl t which we know is a highly reactive compound. Therefore, we have an activated hydroxyl in tertiary 8 alcohols and w© would expect condensation. Similarly less condensation Would be expected with secondary alcohols and still less with primary ones, Experimental results are found to support this view for in gen— era! tertiary aliphatic alcohols condense more readily and with higher yields than secondary aliphatic alcohols while condensation of primary aliphatic alcohols takes place only under much more drastic conditions* that the carbon and oxygen bond in tertiary aliphatic alcohols is reactive is also supported by the ease of dehydration of such alcohols and the ease of replacement of this hydroxyl group by halogen of a halogen acid* Since condensation first teas observed between tertiary aliphatic alcohols and aromatic hydrocarbons there have been several mechanisms advanced to explain the course of the reaction* none of which have been conclusively^ established. Due to the use of different catalysts* tem­ peratures and solvents the results are not always strictly comparable, but there have been evolved three possible mechanisms that merit atten­ tion* These mechanisms for convenience will be designated as follows* 1* Alkyl halide formation plus Friedel-Crafts Reaction 2. Aiken© formation plus condensation 3* Ether formation plus rearrangement and will be discussed briefly, confining the presentation to that appli­ cable to tertiary aliphatic alcohols with the understanding that the mechanism for primary and secondary alcohol condensation may or may not be similar to those given for tertiary alcohols. Each of these mechanisms is an attempt to explain the path by which condensation can take place with the net result of water being 9 split off between the hydroxyl group of the alcohol and the para hydrogen of the aromatic ring a© I. RjCOH + HC6H4QH 13-> R5C-C6H4OH + H^O While AlClg is a good, dehydrating agent this simple conception of intermolecular cleavage of water as represented above does not account for all the phenomena of the reaction nor does it suggest how the elimination of water is actually accomplished. 1* Alkyl Halide Formation plus Friedel-Crafts Reaction This mechanism was proposed by Tzukervanik and Haaarova (25) who observed that after the first phase of the condensation between tertiary aliphatic alcohols and benzene there were present all the components, such as analkyl halide, olefin, an excess of AlGl^ and HC1required for the Friedel-Crafts reaction and the condensation of olefines witharomatic hydrocarbons. From this they outlined a scheme of reaction applicable to any tertiary alcohol and benzene. Illustrated with tertiary butyl alcohol it was II. {GH5)gCOH +> AlGlg ---> AlClgOC(CHg)3 + HG1 lit. A1G1^)G(0H5)3 > CHgGzCHg + AlGlgOH es3 I?. CH«? + HG1 ^ (GHg)gG-Cl tT* (CHg}gG—Cl *f CgHg-- > (GH3)gC—CgHg + HG1 However, this mechanism is not completely satisfactory for it seems unlikely that an aluminate can form as in equation II. In view of the fact that it is not easy to replace the hydroxyl hydrogen of a tertiary 10 alcohol. Further, Hedrick (26) in this laboratory attempting to test the validity of Tsukervanik1s conception added a tertiary alcohol to aluminum chloride suspended in an inert solvent and observed almost instantaneous evolution of hydrogen chloride and heat. This evolution of hydrogen chloride would not be expected to occur if the alkyl halide formation was an intermediate step* It is significant also that an addition of a solution of phenol in petroleum ether to the same mixture did without evidence of further reaction, give 18 percent of the alkyl phenol expected which was a much smaller yield than that obtained under ordinary conden­ sations between the same alcohol and phenol* 2. Alkene Formation plus Condensation The mechanism of alkene formation was offered by McKenna and Sowa (£7) for the alkylation of benzene using alcohols and boron trifluoride as a catalyst and is applicable to either primary, secondary or tertiary alcohols. Shown for normal butyl alcohol it is F I . CHgC^CHgCHgGH — BF ^ 4 G%SHgC=CH£ + HgG BF* VII. CHgCHgCH^CHg + C6H6— CHs CH5CH2-C-C6% H That normal and secondary alcohols give identical products as do iso and tertiary alcohols is evidence of this mechanism. McGreal and Miederai (28) have suggested a like mechanism for the use of ZnClg as a catalyst and Welsh and Drake (29) believe this path is probable in the condensation of aryl substituted carbinols with phenol in the presence of aluminum chloride. Where the alcohol employed 11 is incapable of dehydration eg- benzyl alcohol, benzhydrol, ana triphenyl earbinol they suggest the reaction may proceed in effect by elimination Of water from the hydrorxyl group and nuclear hydrogen a procedure which they use to account for the reaction between triphenyl earbinol and phenol at elevated temperatures without a catalyst* Certainly unsaturated hydrocarbons do Gondense with aromatic hydro­ carbons using aluminum chloride as a catalyst as shown by numerous workers (5Q). Evidence against such a mechanism is slight but it should be men­ tioned that McKenna and Sowa used a catalyst other than aluminum chloride and a much higher temperature than employed in the Huston method and con­ sequently obtained condensations between primary alcohols and benzene. In contrast Huston and Sager (9) have shown that primary alcohols will not react with benzene in the presence of alurainum chloride under ordi­ nary conditions* Olefin formation and alkyl halide formation as intermediates are not mutually independent in all cases, for according to Grosse and Ipatieff (51) the presence of a hydrogen, halide is often necessary for reaction* In which case they assume its action to consist in the addition to the olefin to form an alkyl halide which then reacts with the aromatic hydrocarbon whose G to H bond is activated by the metal halide* Ether Formation plus Rearrangement Briefly this mechanism consists In the formation of an ether of phenol end then its rearrangement into the substituted phenol itself* It seems probable that if alkyl ethers were formed as intermediates they 12 might rearrange into alkyl phenols for Smith (52) has reported the re­ arrangement of ra—oreayl Isopropyl ether, tertiaiy butyl isobutyl se­ condary butyl —, isopropyl phenyl ethers and p-cresyl isobutyl ethers when treated in the cold with aluminum chloride* He prepared th© ethere by treating an alkali salt of the phenol with an alkyl halide* VIII* CgHgOtfa + RC1 » G6H5QR + MaCl Rearrangement was effected by the addition of an equal molecular amount of aluminum chloride. Similar works are numerous (33)* However, the formation of alkylphenyl ethers as intermediates is questionable* Her* and Weith (34) did report a yield of 10 to 12 percent of diphenyl ether from aluminum chloride and phenol at reflux temperature* Nieviand (35) using boron fluoride with phenol and methyl, ethyl, and isopropyl alcohols obtained ethers and substituted ethers. Dehydration was given as the first step in the progress of this reaction. Gl&sien (33) has pointed out that In alkylating the alkali salt of phenol with a halide of an unsaturated alkene the ether Is not a neces­ sary intermediate for phenylalkyl ethers under the conditions of forma­ tion do not rearrange to alkyl phenols. Thus allyl bromide and sodium phenolate in a medium of alcohol gives a 90 percent yield of the allyl ether but in benzene medium there is only a 30 percent yield of the ether and a 70 percent yield of ortho allyl phenol. It is significant also that Huston has reported good yields of the alkylated hydrocarbon in the condensation of tertiary alcohols and benzene, anisol© and m-croaylsiethyl ether (1) end the condensation of benzyl alcohol with anisole and phenetole (8) in which reactions there IS is no possibility of ether formation* Also no alkylphenyl ethers have been isolated even in traces in this laboratory from aluminum chloride condensations between tertiary aliphatic alcohols and phenol {1, 2, 5). lit general no mechanism yet reported seems completely satisfactory* In this laboratory (26) some work has been done in an attempt to ex­ plain the color phenomena observed in condensations between phenol and tertiary aliphatic alcohols as due to the formation of a complex ion or molecule much as phenol forms with ferric chloride, but such an ex­ planation is supported by very little evidence* A similar mechanism with the formation of addition compounds and ionization has been sug­ gested by Daugherty (57) for the Friedel-Crafts reaction.That the path of condensation between tertiary aliphatic alcohols and phenol and those same alcohols and benzene is different seems highly probable based on th© observation of reaction progress* The color formation noted in condensations with phenol has not been observed in condensa­ tions with benzene nor has the splitting of long branched allyl chains been demonstrated in condensations with phenol* At present in this laboratory (38) a mechanism based on addition products between aluminum chloride* alcohol, and phenol followed by rearrangement is being considered* The idea is new only to this parti­ cular field for addition products with AlCl^ have been reported (39) and their existance and formation postulated as an explanation of the catalytic action of several catalysts (40) - In brief this theory is; that a catalyst unites with the substance catalysed through some of the electrons of the outer shell of one of the atoms of the molecule* M The sew arrangement of electrons end atoms In th© fTpolymoleoulen is net stable at the temperature of inaction, and rearrangement of atoms as well as electrons then take place to form systems which are more stable* The theory as applled^ln this particular field is promising and timely* 15 Experimental Data Materials Korm&l amyl, isoamyl, secondary amyl, and active amyl bromides were prepared from the correspending alcohols (Eastman, technical) by the action of sulfuric acid and hydrobromic acid (41). The bromides of diethyl earbinol and methyl isopropyl earbinol were prepared by treating the earbinols with phosphorous tribromide. Diethyl earbinol was Eastman technical (B* P. 110 -117° G) and the methyl isopropyl earbinol m s prepared by a GriguardReactionbetween isopropyl bromide and freshly prepared aeetaldehyde (4£). Tertiary amyl chloride was obtained from tertiary amyl alcohol (Eastman B* P. 100 — 102° G) by treatment with, concentrated hydros chloric acid (45) or by passing dry hydrogen chloride gas into the alcohol (44). Tertiary butyl alcohol Eastman M. P. 25 - 25° 0 was used without distillation to prepare diisobutylene. Acetone used was of G. P* grade dried over sodium sulfate and twice redistilled* Magnesium turnings especially prepared for Griguard reactions were used after being dried for several days over O&Clg* Benzene was thiophene free, 0* P. grade* Petroleum ether, B* P. 50 - 65° C. Ether for Grignard reactions was anhydrous. Each of the last three chemical© was dried over freshly cut sodium before use. Methyl iodide and acetyl chloride were both Eastman*s and used without farther purification. 16 Phenol was twice redistilled and a one degree fraction used* Aluminum chloride was Merk*s Reagent anhydrous sublimed* Alcohols condensed wares A* 2-methyl hept&aol-fc B* 2, 5-dimethyl hexanol-2 0* 2, 4-dimethyl hexEnol"^ JD* 2, 5—dimethyl hexanol"*-^ E* 2-methyl—5~ethyl pentanol-2 E* 2 , 4, 4-triiiiethyl pentanol—2 G* 2 , 3, 4-trimethyl pentanol-2 H* 2, 3, 3-trimethyl pentanol—2 A* GH* - 2-methyl heplanol-2 HI 0 - CH* - CHo - C - GH« This aleohol was prepared by use of the Griguard reaction using the Whitmore method (44) for preparing the Griguard Reagent and the Edgar procedure (45) for the reaction of this reagent with a ketone and subsequent hydrolysis of the resulting compound* As this proce­ dure was used with slight modifications for the preparation of several alcohols it is described in detail* In a * dry three-liter three-necked round bottom flask fitted with an efficient stirrer, reflux condenser, and dropping funnel are placed ^Extreme care must be taken to insure dry apparatus and reagents. Also the reaction must be protected from the carbon dioxide and water vapor of the air* 1? first a few small crystals of iodine and then 98 gee (4 soles) of fresh magnesium turnings {dried over GaCI^)* The bottom of the flask is heated with a small flame imtil the iodine commences to vaporise and is then allowed to Cool while the normal amyl bromide is weighed out* Thirty cc of a mixture of four moles of the halide and SGO cc of anhy­ drous diethyl ether is then added directly to the dry magnesium. After the reaction has started and progressed for a few minutes 200 ee of dry ether is added directly to the reaction mixture* Then, 475 cc of the above halide ether solution is placed in the dropping funnel and added with stirring at the rate of a drop every second. The remainder of the halide ether solution is diluted with 300 ee of dry ether and added at the same rate* Ether refluxes slightly during the haiide-ether addition no external cooling being applied* It is un­ necessary to heat the mixture after the ether-h&lid© solution has been added but stirring is Continued four hours and then the mixture let stand overnight before proceeding. After the solution has stood overnight to it is added at the rate of a drop a second four moles of very pure acetone in an equal volume of anhydrous ether* It is again let stand overnight and the next day decomposed by pouring on water and ice* The precipitated magnesium compounds are dissolved by adding 10 percent HCl,(keep cool with ice during the addition.)* The ether layer is separated, washed with dilute sodium carbonate, followed by distilled water and dried finally anhydrous sodium sulfate* over 18 Fractionated under reduced pressure ** a four mole run yielded 194 gms (37 percent) of a product B* P* 78 - 80° C at 30 mm. Checked as to physical constants this corresponded to the earbinol as described in th© literature (46) and as prepared and reported in this laboratory by Huston and Sculati (£1)* B* 2» 5-dlmethyl hexanol-£ H H 6 GH5 - CHg - C % - G - q - GHS G % CH3 Using the above described method for E-methyl heptanol-E the bromide of methylpropyl earbinol (secondary amyl alcohol) was substituted for normal amyl bromide* field from a four mol© preparation 80 gms (15 per­ cent of theoretical) boiling at 68° C ©t 15 smu This product cheeked as to physical constants with that prepared by Clark (47) and prepared also in this laboratory by Huston and Sculati (21)* C* 2* 4-dimethyl hexanol-2 H H 0 e % - GHg - c --■ C - CH3 Prepared according to the method used for 2-methyl heptaaol-2 sub­ stituting the bromide of secondary butyl earbinol (active amyl alcohol) **These tertiary alcohols dehydrate to some extent when distilled under atmospheric pressure* 19 for normal amyl bromide* Held from 4 moles was 72 gms (14 percent) of a product boiling between 155 — 156° C at 748 mm* The physical con­ stants of this product checked with those of the same earbinol prepared in this laboratory (21) and reported in the literature (48). 0* 2* 5-dimethvl hexanol-2 H CJHg — 6 — CHg — CHg H 0 — G — OHg GSg Prepared according to the already described method* bromide used in place of normal amyl bromide. Isoamyl A four mole run yielded 268 {55 percent) of a product B. P. 68 - 70° C at 12 mm. This was the 2, 5-dimethyl hexanol-2 as its physical constants cheeked with those obtained in this laboratory by Huston and Sculati (21) and reported in the literature (49). B* 2-methyl—5—ethyl pentanol-2 If a o G % - C % - d - C - CHg ?®£ ® S CHS Prepared according to the already described method, using 5-bromopentane in place of normal amyl bromideB* P. 60 - 64° G at 15 mm. field 7 percent of a product This was used as the earbinol as it corres­ ponded to that prepared in this laboratory by other workers and re­ ported in the literature (50). 20 P. £. 4. 4-trlmethyl neat£U3oI-£ CH5 ch5 - g 1 ghe OH5 H 0 - c - ch 5 OH 5 This alcohol was prepared by the method of Butlerow (51) with slight modifications. Two parts by volume of a quantity of like volumes of sulfuric acid and water were mixed with one part by volume of tertiary butyl alcohol and Hie mixture placed in a round-bottomed flask fitted with reflux condenser and heated for twenty-four hours on a steam bath, appeared. two layers The layers were separated by means of a separatory funnel and the top oily layer was saved* After being washed with water it was dried over anhydrous calcium chloride* It was then further dried by- use of phosphoric acid anhydride followed by refluxing over freshly cut metallic sodium. The product was fractionally distilled and that portion boiling 102 — 104° C at 756 mm was saved &a diisobutylene* Into the diisobutylene at 10° C was passed gaseous hydrogen iodide, generated by allowing water to drop on a mixture of red phosphorus, iodine and send, until the diisobutylene was completely saturated with hydrogen iodide. The resulting iodide was washed with water until all unused hydrogen Iodide had been removed. Then to the iodide was added the calculated amount of moist silver oxide. quantities with vigorous stirring at 0° C. This was added in small zx The resulting mixture was allowed to warm up to room temperature sad. all the liquid removed from the precipitated silver iodide by vacuum distillation. parated. This distillate consisted of two layers which were se­ The water layer was extracted three times with ether and this extract was added to the oily layer which, after being dried with anhy­ drous sodium sulfate* was freed of ether at ordinary pressure and then fractionally distilled. From eight moles of tertiary butyl alcohol was obtained 164 gtas (51 percent) of a product B. P. 51° C at 15 mm or 144° 0 at 758 mm* This fraction was used as £, 4, 4-trimethyl pentanol-2 as it corresponded to the literature reported carbinol (51) and the earbinol as prepared by other workers in this laboratory. Jhu 5. 4-trtmethyl pentanol-g I H | as, - c - e - o CHS QHj CHg This alcohol to the writer* s knowledge has not been reported in the literature so several methods were tried. Of these the preparation of of 4-dimethyl pentanone-£ and its reaction with methyl®agneslum iodide was the most satisfactory and will be described in detail. 1. Preparation of 5, 4-dimethyl pentanone-£. A Grignard reagent was prepared in the usual fashion (44} using 798 gas of 1 — m e t h y l - J—bromobutane. by the Gilman The yield of C-rlgnard was determined method (5£) of titrating a hydrolysed aliquoit, to be 4X£.S gas or a 45 percent yield* 22 Using a modification of the tShitmore—Bradertscher procedure for preparing ketones (44) the Gri^aard reagent was added to 250. 5 gas (2*95 moles) of acetyl chloride dissolved In 70S ee of dry ether contained in a five-liter three-necked round-bottomed flask fitted with reflux condenser? separatory funnel, and mechanical stirrer. This addi­ tion was at such a rate that the ether refluxed and after three-fourths of the reagent was added, an additional 50 cc of acetyl chloride was A white placed in the reaction flask to insure its presence in excess* precipitate formed which turned yellowish later in the reaction* The solution upon completion of addition of the reagent was allowed to stir for four hours and then stand overnight* The precipitate and filtrate were then poured on ice, the ether layer separated and the water layer extracted three times with ether and added to the ether layer. The combined extracts were washed with one- fourth of their volume of saturated aqueous potassium carbonate solution* The solution was dried with anhydrous potassium carbonate and the ether was then removed at ordinary pressure. The remaining residue was steam distilled with aqueous potassium carbonate solution and the ketone was salted out of the distillate with M&G1, separated from the water and dried overnight with anhydrous sodium sulfate at zero degrees* It was then fractionally distilled collecting the fraction 155 — 140° 0 at 744 mm* This fraction weighing 55 gms was a yield of 3.5 percent based on l-sethyl-2-bromobutaae. 2* Preparation of 2> 5, 4—trime thyi pentanol—2* Methylmagnesiuai iodide was prepared in the usual fashion by allow— -i a dry ether solution of methyl iodide *&o react wrth magnesium* In 23 this case 0.7 of a mole of methyl Iodide was used. To the Grignard reagent in a two—liter three—necked round—bottom flask fitted with a separatory funnel, reflux condenser and mercury— sealed mechanical stirrer was added the 56 gms of ketone obtained above dissolved in an equal volume of anhydrous ether. After the addition which was made not faster than one drop of the mixture a second, the solution was allowed to stand overnight. in the usual manner by being poured on The next day it was hydrolysed ice and the basic magnesium compound removed with 15 percent sulfuric acid* The ether layer was separated from the water layer which was extracted three times with ether. The combined ether extracts were shaken with solid sodium car­ bonate until basic. T he sodium carbonate was then removed by washing with distilled, water and the ether, and- the ether solution dried over anhydrous sodium sulfate. Ether was removed from the product and it was fractionally distilled at 13 mm. tained, boiling point 45 - 50° C* ketone* A thirty-six gram yield was ob­ This was 58*1 percent based on the Physical constants were determinedupon this fraction. Boiling Point — — — 151 — 153° G at 732am tJ.30 Refractive Index ” - 1*4400 20° Specific Gravity - *8532 oqO Surface Tension -28.1 dynes 24 *** 5» 5—trljaethyl peataaoI-2 E CHg 0 CBg — CHg — 0 — "C — tJEg GHs GH3 This alcohol was prepared la two w&ysj first by trsetting tertiary anyl magnesium florid© with acetone (see preparation of 2-iaethyl heptanol-2) ■ and second by synthesising the ketone 5, 5-dimethyl pentanone-2 and reacting that with methyl magnesium iodide (see pre­ paration 2, 5, 4-triaethyl pentanol-2). However, due to the difficulty encountered in obtaining tertiary Grignard reagents very small yields of the alcohol were obtained (2 - 5 percent based on tertiary amyl chloride) * The alcohol thus obtained, however, was in accord with that , ' v v prepared by other workers (55). w -?*)t ^ lable Jk which follows gives several physical constants on the vari­ ous alcohols used in condensations as determined la this laboratory* TABLE k 1 Hefr&eiiv® *« .HpecxTfS"" « Index • 3 . Gravity,_ , ....... ..AicobpA . — BollingJiolci.t..... D t Temper&ture°C 2Pressure nms n 4 K* 2-»ethyl heptanol-2 t 159*5 746 : 1.4255 t .81666 "SB* -f390 j^o 20° a,5-diiiiet||lanol_g .155.5-156.5 m 756 • 3 1.455 • 2,4-dimethyl 20° hexanol-2 * 152 — 155 1 750 .. f 1.4221 1 _.8i2S6_|®’ 2,5-dimethyl • * .81826 746 hexanol-2 : 154.5 * t i W 7-5° « 2-methyl-'6-ethyl £33 O CO S CM P * H C 60 * 00 CM r| * CM •• ■ •• *# botJ S-t © © *H >M M to to * 0» to JO tft to to 4 CO to •* t3 O g m o8 to 99 CM to cm #* ■•*■ ** •• CM to Io &O f f l© Pw (4 t-f *0 o o 1 cq >P 4* © -§ © ** »• «L f S >-< o. p> r d «H P K ^ £ (D >-» S3 CM rj •* *• «• »» £ *» ** « to © r-t »-4O £d ur> Cm tH • CO O • to CM * to a to *u to TS * *• © *• u> * ** » •• »» trH # •» -#* to CM i— I ♦ to CM /H • r-f • rH rH * to CM rH * to CM 60 to * to * CO CM * to * fcQ * to CM to CJ 43 r-t is © 2-a •TS f? * 3O 43 oTi& M CM 1 -a CM CM rH M O 1 to CM &.S CM H CO * s# CO to CM © *» •• CM t to w cm +<* •* *• H to CO rH * to CM H o * ? to »• ■* *o4 . r-t K H © PS3 © CM 0* t >1 © ? CM «• ♦» 99 99 90 Physical constants and analysis of these p-hydroxyphenyl derivatives are tabulated in Table I a. o 28 Derivatives A* Benzoyl Esters Of seven of the alkyl phenols were prepared by a raethod described by Sariner and Fuson (55). The procedure consisted in dissolving three grams of the phenol in 4 cc of pyridine and adding 5 cc of benzoyl chloride* After the initial reaction the mixture was warmed over a low flame, refluxed for one hour, cooled, poured on material extracted with ether. dilute sulfuric ice, and the oily The ether extract was washed with cold to remove pyridine and then cold dilute sodium car­ bonate solution, to remove excess add. After removal of the ether the ester was distilled under reduced pressure from a small modified Glasien flask* Usually upon cooling in the refrigerator the ester crystallized out. It was then removed from contaminating oily material by absorbing such impurities on & porous plate* And finally it was re- crystallized several times from 85 percent alcohol until further recrystallization caused no changes in melting point* Table II gives the data on these esters. B. Alpha—napthylurethaaes These were prepared by the following method (56). One gram of the tertiary octyl phenol was placed in a large test tube and 1.5 cc of alpha-napthyl isocyanate was added the reaction being catalyzed by two drops of a dilate anhydrous ether solution of triaethyl amine. The tube was protected from moisture by being fitted with a 0aClg tube and thus stoppered,the reaction was heated on a steam bath for half an hour, Ifpon cooling the reaction contents became solid. This solid was ex­ tracted with 60 cc of boiling ligroin (6© - 90° 0) and all undissolved 29 material filtered out* Xu the clear filtrate the &!ph^—napthyluretiione crystallized out on cooling. It was filtered off and reerystallized from hot ligroin until a constant melting point was obtained. Results on the3® urethanes are given in Table III. Ho derivatives were prepared of the supposedly 2, 5, 5-trimethyl2-p-hydroxyphenyl pentane as it was obtained in a quantity of less than 0.7 gram upon recrystallization to a constant melting point. Proof of Structure This was accomplished by synthesis of the octyl phenols by another method; namely that of preparation of the octyl benzenes, their nitra­ tion, reduction to toe p-nitro derivative formed to the corresponding p—amino compound, followed by di&zotization and hydrolysis of the diazonium salt to yield the phenol. A description of this process in detail follows. A. Preparation of the Alkyl Benzenes Pour of these compounds had already been prepared in this laboratory and their physical constants determined (£1). However it was necessary to obtain them in larger quantities and to prepare the others of the series. Since their preparations were carried out in a similar manner a typical synthesis is given. In 97 grams (1.25 moles) of benzene in a 500 cc three—necked round-bottom flask fitted with dropping funnel, condenser, mercury-sealed stirrer, and thermometer, was suspended 17 grams (0.125 mole) of aluminum chloride by rapid stirring. To this suspension was added drop by drop 52 grams (0.25 mole) of the octyl alcohol the temperature being maintained 30 below 30° C by immersing the reaction flask in a water bath If necessary. During the addition of the octyl alcohol the mixture first became yellow in color and the AlGlg seemed to go into solution. Then upon further addition a dark brown viscous layer appeared which separated out on the bottom of the flask and the whole mixture became dark brownish in color. Aftex' complete addition of the octyl alcohol the mixture was allowed to stir four additional hours and then to stand overnight. The next day the reaction mixture was poured on acid 1 j parated. 1 to cause decomposition. ice and hydrochloric Two layers resulted which were se­ The water layer was extracted three times with ether and this ether extract added to the benzene layer. The combined ether and benzene extract was washed with dilute sodium carbonate solution and dried over anhydrous sodium sulfate. moved at ordinary pressures and The ether and benzene were re­ then the remainder fractionated under reduced pressures to obtain the alkyl benzene. This procedure was found adequate for the preparation of 2-methyl-2-phenyl heptane, the hexanes 2, 3j 2, 4; and 2, 5-dimethyl2-phenyl and 2-methyl~3-ethyl-2-phenyl pentane but applied to the prepration of 2, 4, 4-trimethyl-2-phenyl pentane and 2, 3, 4-trimethyl2-phenyl pentane splitting of the long alkyl side chains occurred giving products of lower molecular weights. In these cases a modificar- tion of the originally described method was tried with apparently better results. It consisted of carrying out the reaction at a lower tempera­ ture* but,since benzene solidifies at 5° G, it was necessary to use a solvent that would permit the reaction mixture to remain a liquid at sub-zero temperatures. Such a solvent was petroleum ether and the 97 (1.25) moles of benzene was dissolved in 150 cc of petroleum ether in SI which was suspended 17 grams (0,125 moles) of aluminum chloride and the octyl alcohol added as usual. The temperature was maintained between —5 and -10° G by use of a hath of ice and ESI or solid carbon dioxide {dry ice) in which the reaction flask was immersed. The remainder of the preparation was as already described. Bue to the limited supply of these alcohols and the late discovery of this modified procedure to -prevent in part splitting of the alkyl chain, the data presented Is based upon only two condensations and hence is only suggestive of a promising possibility. That the 2, 4, 4-tri- methyl pentanol—2 splits in condensation in such a way that tertiary butyl benzene is formed has been definitely established by isolation ©f this compound* nitration of it, reduction of fee nitrocompound, di&zotiz&tion of the formed amine, and hydrolysis of the diazonlum com­ pound wife isolation of tertiary butyl phenol {$. P. 95 - 96° C) ♦ The benzoyl ester of this phenol when prepared {M* P. 81 * 82° G) was mixed wife known benzoyl ester of tertiary butyl phenol and gave no melting point Change to the known ester. The U, 5, 4-trimethyl pentanol-2 in a similar condensation gave as fee principal product an alkyl benzene B. P. 160 - 170° G at 756 mm which converted to a phenol by a similar series of reactions as those used to convert tertiary butyl benzene to p-tertiary butyl phenol melted at 95 ^ 96° 0. Its benzoyl ester melted at 86 - 87° G. Ho attempt to prepare 2, 3, 5-feimethyl-£-pkenyi pentane was made as the alcohol k, 5, 3-trimethyl pentanol-2 could not be obtained in sufficient quantities* Table G summarizes fee condensationa carried out to prepare the octyl benzenes as to yields and products. 32 p 5 o Ok C D0 U3 CD 10 cv 0* r-t f H CM p to P )© CD cd If• u£l O rH *H O m •» «• © IjQ13 «i H S l> 0* )-fH j* H CD p rH © rH •* *• e-« M > to *• ■* O "E9j te o to P o a rH «* ** tO • CD rH •• •* rH CM P rH a rH •• *• ts• t to o to P rH 0} H •j© ** DO * 60 *• •• *» •• to o Hi •« to • cH •• CM CM to ** r* C 3 tO > to CM ** *• •* *• O to 1 t o CM *<* ** •• ra O O* M3 CM C~• H*]at rH • • • • H tq < PQ * *i CD ft P §1 S-» 3 T3 rH £ © © © rCj h*a •»Xj CM ft W ft •>P W ft «• » « •» » • #» M »• 4 H * vO CM * tO CM » ■ u> C s i « to Oi * B3 tC4 © rH O r-t S3 «S +* © 0) o pO -4 N g 31 cq © a> 0 to » £M *• M to * O i l «* *« to • h *# » iO # ■ to * to to » mm mm «H 0 X 'l S o rH -«1 -P & CM * rH O rH M 3 J © >> K . © Ofl CM CM »o «■ CM CM i iH r fO rg 3 P p © a ® ft t 1 -1 >» © f CM mm f t * t o cm to • ** « • 40 * H 40 • ca ** «* CM HI O mm mm m o* i —4 to f t - tO 40 tf 4 • 40 C S 1 • ** © rH O «• ** M »* to mm pentane *H » » CM rH rH CM * H H >* 0 s s © p s a *H © JH ft P 1 H» f t ^ 3© 413 e a *r4 ft fH P c \ * CM r to 55 The alkyl benzenes thus prepared were nitrated, B. Nitration of the Tertiary Octyl Benzenes Malherbe* s procedure (5$) was used. It consisted of treating the hydrocarbon with an equal weight of fuming nitric acid (1.52) and cool­ ing during the addition. After the reaction had subsided the mixture was warmed to 90° G in & water bath for one hour. It was then poured on ice and the resulting solution extracted three times with ether, These ether extracts were dried over C&Clg and after removal of the ether the remaining p-nitro tertiary alkyl benzenes which were liquids were frac­ tionally distilled under reduced pressure. Boiling points and analyses of these compounds are recorded in Table IV, G. Oxidation of Para Nitro Tertiary Alkyl Benzenes In order to establish the position taken by the nitro group in re­ ference to the alkyl side chain a portion of the nitro tertiary alkyl benzene was oxidized by a method adapted from Malherbe (56), 0ns gram of the nitro compound and 20 cc of 6 N nitric acid was placed in a Carius tube, sealed and heated in a C&rius furnace for six days at 150° C. By this time crystals had formed in the tube which were removed and collected. They were washed with hot petroleum ether to remove oily material and then r©crystallized several times from alcohol. In each case the crystals melted at 258 - 240° C mid mixed melting points with p-nitro benzoic acid showed no depression indicating a para nitro ter­ tiary alkyl benzene as the original compound. D, Reduction of the Para Nitro Tertiary Alkyl Benzenes This reduction to yield the p—amino tertiary alkyl benzenes was accomplished as follows. Thirty grams of tin were placed in & 500 cc rouznl—bottoi&ed flask fitted with &u air condenser* Fro® XO — 15 grans of the p—nitro tertiary alkyl benzene was added and than 100 cc of concentrated hydrochloric acid in two portions* After the initial reaction had subsided the mixture was placed on a steam hath and left for four hours* it the end of this time it was treated with a large amount of water (£GQ — 200 cc) cooled and made alkaline with 40 percent sodium hydroxide* was then steam distilled* This alkaline solution The amine was extracted from the distillate with ether and the ether solution of the amine was dried over solid potassium hydroxide* After removal of the ether the residue was frac­ tionally distilled from a 10 cc Glasien flask with a 12 inch column* Re­ sults as to boiling points and percent nitrogen of these amines are summarized in Table 7* E* Phenols from the Para issiao Tertiary Alkyl Benzenes These mines were diazotised and then the diazoniua salt hydrolyzed to form the phenol* A typical procedure is as follows* The amine was treated with concentrated sulfuric acid 1*5 cc is 10 cc of water for each 2 grams of the amine* The solid salt thus formed was quite in­ soluble in water but it was suspended by vigorous stirring in 10 times the volume of the mixture of water, amine, and sulfuric acid* After cool­ ing to about 5° C a 25 percent solution of sodium nitrite was added dropwiee with continued stirring over a five hour period until the calculated amount to act with the amine had been reached* Stirring was then continued for two hours more and finally the diazotized solution was warmed on a steam bath for an hour* steam distillation. This reaction mixture was then subjected to The phenol was extracted from the distillate with 35 ether and after drying the ether extract with anhydrous potassium sulfate it was fractionated under reduced pressure to obtain the pure phenol, F* Derivatives The alpha-**apthylurethanes were prepared using 0,5 grams of the phenol obtained and their melting points determined. In all cases these melting points were identical with those of alpha—napthylurethanes pre­ pared from phenols from the aluminum chloride condensations of alcohol and phenols already described. Mixed melting points showed no depres­ sions and hence the phenols as synthesized by the two different methods were identical. Absolute proof in this fashion was established for £-©ethyl-2-p-hydroxyphenyI heptanej Z, 3-dimethyl, 2, 4-dimethyl and 2, 5-d.imethy1-2—p-hydroxyphenyl hexane; and g-methyl-3-ethyl and 2, 4, 4-trifflethyl-2-p-hydroxyphenyl pentane. Further proof of the structure of 2, 4, 4-trimethyl~£-p-hydroxyphenyl pentane was obtained by synthesizing it as described by Satelson (24) as follows; G. Synthesis of 2, 4, 4~trimethy1-2-p-hydmxyphenyl pentane, A mixture of one mole of powdered potassium hydroxide and one mole of phenol was heated at 65 - 100° C in a 500 ee round-bottom flask im­ mersed in an oil bath until solution was complete, Then a mole of di­ isobutylene chloride was added drop by drop at a temperature of 75° C until the reaction was complete. Potassium chloride separated out. The temperature of the b&th was raised to 125° G, kept there for three to four hours and then raised to 180° C where it was kept for one hour. After cooling the potassium chloride was dissolved in water and the separated crystalline product was purified by pressing out oily im­ purities and recrystall!zatioa from petroleum ether. This product 36 according to Natelson is 2, 4, 4—trimehhyl-£—p-hydro:zyphenyl pentane or diisobutylphenol, IS, P* 34° G* Benzoyl ester and alpha-napthylurethane derivatives had melting points corresponding to those derivatives prepared fro® the 2, 4, 4trii^thyl^E-p^ydroxyphenyl pentane obtained as a product fro® the con­ densation of 2, 4, 4-trimethyl pentsnol-g and phenol with aluminum chloride as a catalyst* Mixed melting point determination showed these phenols and corresponding derivatives to be identical. No absolute proof is offered of the structures of 2, §, 4-trjjaethyl or Zf. 5, 3-tri»ethyl-2-p-hydraxyphenyl pentanes due to the difficulty in obtaining the alcohols £, 3, 4-trimethyl pentaaol-E and 2, $, S-triraethyl pentanol-2, la the former case splitting of the alkyl chain upon conden­ sation with benzene prevented preparation of the alkyl benzene in suffi­ cient quantities sad in the latter all the alcohol prepared was used in condensations with phenol. 37 TABLES 38 co » >* (8 r-t o ■**! 4 O ■rf Ch-P •Qrt*rt© I o r-t OS to ♦ o r-4 «c «• * s-m ca * CD &0 0 * i- t 00 ** •• u- «0 SO CO c~ ca ts> OS • to os * 6Q 00 H tO OS * mm *• «• §* os co s OS #- QkU mo 00 OS c~* o CO to to © ctfcaca as to « o r t o o m CO CD r t* * O r-t « o r~ t m» ca c£> * o H 00 CO • o r-l #*• o os * Q §5 (O OS * o CO •• CD (S * o <30 m mm O M I to * CIO CO OS * t ** *» t 8 •H m J> o ** $8 qi a to OS ca «#- •* i 1 i I M #• •# mm sa Q* © r-t O 1 t t I I t •* « CD ca to ca a* •• SO CO -st» o- «• *• CD ** io OS ca to %• 02 a >* 0© }>> 8 £ to S • t0 S mm *» Wt OS c a •* M 3 M 091 3 •H F-t P« l>>a» 3 ca xn *tJ O ?>* ^ !>> ca xi 02 xi ca xJ to xi ca jd ca xi • a o o © a C = 81.48? e> 4> 5 •• Ceao. for C14Hg20 •* H r 10.76J5 *© 59 TABLE I I smmiL m m & s Benzoyl Ester of x !*P.° C s Analysis Fqus&B* 2-»ethyl-2—p-hydroxyphenyl heptane t% 0 i % M .... . s 22 - 23 i 80*55 i 8,27 2>3-dimethyl-3-|>4aydroxyph.enyl hexane x54*2-55,2? 01,22 s 8,55 2,4-dimethyI-g-p-hydroxyphenyl hexane * 57 - 50 s 81,28 * 8.41 2,5-diraethyl-2-p—hydroxyphertyl hexane x 46 * 4? x 81,18 f 8.26 2—methyl-5—ethyl-2~p—hydroxyphenyl pentane t 69 - 70 t 01,19 i 8.59 2,4,4—trisethyl-E-p-hydroxyphenyl pentane x 75 - 74 t 80,66 t 2,S,4-trim9thyl~2-p-hydroxyphenyl pentane X 47 - 48 x 80*43 t 8.18 * GaiccL for G ^ s a ^ S C r 81*E2$ 8*22 Hr 8.45$ TABLE III ALPHA-®APTHILURETriANES AlphaHmpthylurethan.es of s H. P,°C : Analysis Found* x : % ® 2-methyl-2-p-hydraxyphenyl heptane x 120-121 s 5.69 2,3-dimethyl-2-p-hydroxyphenyl hexane x105-105.5x 3*75 2 ,4-dimethylr-2—p-hydroxyphenyl h exane x119,5-120.5s 3.72 2,5-dimethyl-2~p~hydroxy phenyl hexane X132.5-1S3* 5; 3.70 2-methyl-3-ethyl-2-p-hydroxyphenyl pentane xl09,5-110,5x 3,70 2,4, 4-trijaethyl-2-p-hydroxyphenyl pentane t 102-103 a * 3.69 2,3,4-trinethyl-2-p~hydroxyphenyl pentane I114*5-115, 5s 3.68 * C&Xod* fox* ^26^29^2^ H= 3.75 56 40 table m PAEA NITBD TEETIAEX GGTYL BENZENES S u b s ta n c e B o llin g t t? e m p .° G m e t h y l- 2 > 3—d 2 , 4- d im e th y d L m 2 —m e th y l- , p - a it r o p h e n y l h e p ta n e i m e t h y l — 2 —p —n i t r o p h e n y l 2 , 5- 2, 4 2- 4- * C a lc d . s 143-1508 2 * 6*01 h e x a n e s 153- 155 * & t 5*99 p - n it r o p h e n y l h e x a n e 8 155- 157s 2 3 5*98 2~ p ~ n itr o p h e n y l h e x a n e t 129-1518 2 8 6*09 : 127- 150? 4 f 6*09 3 108-1103 4 3 6*05 3—e t h y l —2- p - n i t r o p h . e n y l t h f o r 2- y l - p - n it r o p h e n y l C -^ H g jO g R p e n ta n e p e n ta n e 5 . 95% S r TA B LE PA EA a m in o V t e e t ia e i o c t y l D E L E T E S » #- S u b s ta n c e B o ilin g 5 *r e * 2- m e th y l- £ , 3- 2 , 4- d 2 , 5- 2- 2 , m 4 d im 4 -a m in o p h e n y l e t h y l- - t r im * C a lc ;d . 5- s P re s s u re ; N : ? 2 8 6.77 9 s 4 8 6.58 h e x a n e 3 H U % F o u n d * mm 108-111 5- : A n a ly s is 2- p -a m in o p h e n y l h e x a n e 3 99-101 8 2 3 6*87 2- p ~ & r a in o p h e n y l h e x a n e : 99-102 s 2 : 6*92 8 105-106 ? 2 3 6.86 8 8 5 3 6*72 e th y l-£ -p -a m e t h y l - f o r m p .° C P o in t ........ 5 : h e p ta n e e t h y l —2- p - a m in o p h e n y l e t h y l- , 2—p im e t h y l - d im 5 % mm 1 - 2- e th y l- t r i j ^ F o u n d * : P re s s u re : j 2- fe n a ly s is P o in t 2- p C -j^ il^ N in o p h e n y l -a m in o p h e n y l p e n ta n e p e n ta n e N z 6.82 % l l g -115 41 Discussion The general procedure employed in preparing the tertiary octyl phenols described in this work consisted of the preparation of the various dimethyl amyl tertiary carbinols fallowed by their condensation with phenol in the presence of aluminum chloride as a catalyst* H fl CEs-C-GHg-C-C6H4°B chs <®3 OHg-9 - C - C - CgB^OH t Eg} H H CHv V * 06H5O H ----- > GHg-CH^-C ~ 0 - CeE4GH 4 H^O G % CHg Good yields resulted when the condensations were carried out at 25 — 50° 0$ lower temperatures 10° C were observed to decrease the amount of alkyl phenol* Of the phenols prepared five were liquids ana did not crystallize even when subjected to ice box temperature• However* they were very viscous requiring several distillations to obtain pure fractions* The alkyl phenols after purification were analyzed for G and H#Their physical constants were determined and derivatives were made* The benzoyl esters and alpha-napthylurethanes were preparedfor means of identification of all the phenols except 2, 3, 5-trim©thyl-2p-hydroxyphenyl pentane* Since these derivatives were all solids their melting points were determined and they were analyzed,j the benzoyl esters for percent C and H end the alpha-iiupthylurethanes for percent nitrogen* Data on those phenols and derivatives is contained in the tables accom­ panying this* thesis* Absolut© proof of the structure of these alkyl phenols was accom­ plished by synthesizing them from the corresponding alkyl benzenes prepared by condensations between the already listed carbinols and ben­ zene .In the presence of aluminum chloride* In this procedure it was 44 noted that highly branched &11 ph&tio chain£ often undergo splitting resuiting la product® of lover moleGul^x weight* This was especially true in the css© of Z, 4# 4-trimethyl pe2itanol~~£ and I, S, 4~tri»ethyl pentaaol~£* Temperature appeared to affect this splitting;at lower temperatures -10° Q it occurred to a leaser degree than at £5 - 30° C* These alkyl benzenes whan purified were nitrated with flatting nitric a d d giving 'the p&ra-dtro derivative* That substitution of the sa* group into the benzene ring took place para to the alkyl chain was proven by oxidation of a portion of the nitro derivative with dilute nitric a d d in a C&rius furnace to give in every case p-nitro benzoic add* The para-nitro derivative was then reduced with tin and concentrated hydrochloric to the p-tertiary oetylphenyl amine which upon diazotizatlnn and subsequent hydrolysis of the diazonlua salt yielded an alkyl phenol* These phenols were then identified by their dpha-napthylurethaaes nixed editing point determinations indicating that they were identical with the urethanes sad© from the phenols obtained by direct condensation of phenol with the various earbind a under the action of almalnua chloride* Am - amyl groupings c% m n * m ~ c ~ c6ss f « - CgH4U02 cb5 +■ moz--------- — > a® - c - Oxidiaeci MJSEemi 0 V * - C - CsH^g 45 XX. XXI* <*5 Am - C - C6H4HO£ - Reduced Tin + HG1 Am - C - CeHgCH Hydrolyzed with EOH cr3 ®5 la this fashion was established the structure of six of the alkyl phenols namely* 2-®ethyl-2~p-hyaroxyphenyl heptane} 2, 3-dimethyl~2-phyciroxyphenyl hexane 5 2, 4-dimethy1-2-p-hydroxyphenyl hexane} 2* S-dimethyl—£-p-hydroxyphenyl hexane} 2-ffiethyl-5-*ethyl-2-p-hydroxyphenyl pentane and 2, 4* 4-trimethyl-2—p-hydroxyphenyl pentane* Mo absolute proof of the structure of £, 5, 4-ti'isethyl—2-p-hydroxyphenyl pentane end Z, 5, S-trimeihyl-£—p-hydroxyphenyl pentane was possible due to the difficulties encountered in preparing £> 5, 4-tilmethyl-2phenyi pentane and 2, 5* 5-trimetbyX~£-ph«nyI pentane* However, since the preparation of these alkyl phenols was similar to that used to pre­ pare those whose structures have been definitely established in six separate cases the writer feels that they are undoubtedly the compounds as designated* 46 Summary 1* Same tertiary dimethyl amyl c&rbiaols have been condensed with phenol in the presence of aluminum chloride to yield p~tert±ary octyl phenols* 2* 2-methyi~2—p~hydroxyphenyl heptane| 2, 3-&iaethyl-2-p^hydroxy*phenyl hexane j 2, 4-dimethyl-£^p-hydroxyphenyl hexanej tP 5~dImethyl-2-p-hydroxyphenyl hexane| 2-®ethyl-$-ethyl~2-p--hydroxyphssyl pent&nej 2t 4, 4-triraethyl-2-p-hydi^:^phenyl pent&nej g, 5, 4-trim8thyl~£-phydroxyphenyl peatanaj and 2, 3* 5-trimsthy1-2-p-hydroxyphenyl pentane have been prepared in this way* 3* Bensoy1 ester and &tpha~n&pthyXurethanes have been prepared of ail the alkyl phenols except 2, 3-trimethyl-g-p-hydroxyphenyl pentene. 4* Proof of structure has been advanced for the phenols excluding the £, 5,. 3-trimethyX and 2, 3, 4—trimethyl-2-p-hydroxypheny1 pentanes by synthesizing them in another way * Bibliography 4? 1, Huston sad Hsieh «T. Am* Chen* Soe. m 459 (1956) tu Huston sad Hedrick J* As. Chem. Soc, m 2001 (1957) 5. Huston sad Anderson 4* Auer Master* & Thesis, Milligan State College Bar* 17 689 5* He£ Ann* 6. Huston and Friedmann (1936) (1884) 296 £55 (1897) J* Am. Chem. £oc. 5S mz7 (1916) 7* Huston and Friedmann J. Am* Ghem. Soe. 40 785 (191$) 8, Huston J. Am* Chem. Soc* 46 £775 (1924) 9. Huston end Eager J. Am, Ohem, Son* 43 1955 (1926) 10* Huston and H & m a x m H * Huston, Lewis, Grotemut IE* Huston sad Bavis IS* Huston sad others Master*s thesis, Michigan State College J* Am* Chem. Soc* 49 1566 (1955) Master* s diesis, Michigan State College J« Am* Cheia. Hoc. 85 2579 (1955) (1927) (1951) Ibid 57 4484 (1950) Ibid 54 1506 (1952) 14* Huston and Goodemoot J* Am, Ghem. Bo c* 56 £432 (1954) IS* Huston and Wllsey Master*s thesis, Michigan State Master* s thesis, Michigan State Master*s thesis, Michigan State Master*® Thesis, Michigan State J* Gen* Shea. USSR 7 16* Huston and Hradel 17* Huston and MeComber 18* Huston and Fox 18* Taukervanik and others 20* Huston and Binder 21* Huston and Sculati (1955) College (1954) College (1935) College (1954) College 632 (1937) (1935) Ibid 5 Ibid 5 117-120 (1955) 764 Master*s Thesis Michigan State College Master’s Thesis Michigan State College (1955) (1956) 48 22. Huston end Breirting n * Heater Masters Thesis, Michigan State College 0* S* Patent £,008,017 (19SS) 24* Hatelson J * Am* Chem* Soc, 1583 (1934) £5* Tzukervanik and Haz&rova {1935} (1936) (1957) £7* McKenna and Sown J. Gen* Chem OSSE 5 117-20 C. A* 30 443 Doctor^ Thesis Michigan State College 1* Am* Gheau Soc* 33 470 (1986) 28* HcGreal and Hiederal J. Am* Chem* Soc* 57 2625 (1935) £9* Welsh and Drake J* Am* Chem* Soc* 60 59 (1939) 30* Berry and Held ij* Am * Ch6Ei* Soc* 43 3142 (1927) 164 1375 (1886) £6* Huston and Hedrick 56 (1938) Varet and 7iemi© Coiapt. rend* Cline and Held J> Am* Chem* Soc* 45 3150 (1927) J* Am* Chem* Soc* 43 3157 (1927) 186 1005 (1928) Bo&roux Compt* rend* 31* Grossa and Ipatieff 3* Organic Chem* 1 562 (1957) 52* Smith J* Am* Chem* Soc* 55 415 (1933) S3* Hiederal and Hatelson J* Am* Chem* Soc* 55 1328 (1931) Sowa and Hiewl&nd, J* Am. Chem* Soc* 54 2019 (1932) Claisen Z aagew* Chem* 36 478 (1923) Dialsen Ber# 58 275 (1925) Glaisan Ann* 418 £3-120 (1919) Early and Mama J* Am* Che®* Soc* 57 371 (1935) Hiewlaad J* Am* Chem, Soc* 55 5420 (1933) 34* Merz and Weith Ber. 14 188 (IBM.) S3* Niewland J* Am.* Cheis. Soc* 57 703 (1936) 36* CXasien % angew* chem* 06 478 (1923) 37* Daugherty J, Am* Che®. Soc* 51 576 (1929) 58. Huston and Evert Masters Thesis Michigan State College (1938) Adkins J. Am. Ghana* Soc* Gustatfeson 1. fur* Prakt* Chem* Schleicher and Buttgenbaeh IMd m . Laagmuir 44 2175 (1922) 2 68* £08 {1903} 355 im {1925} Trans. Far&diay Soc* 17 Michael J. Am. Chem. Son* 40 42 Adkins J. Am* Chem* Sac* m 137 (1924) 607 615-619 655-654 1697 im (1922) (1918) (1920) 41* Organic Synthesis Coll. Vol. I P* £5 42* Organic Synthesis Volume XII P* 46 45. Organic Synthesis Coll* Vol. I P* x m 44* Whitmore and B&dertseher J* Am, Chem. Son* m 1561 (1933) 45. Edgar J * Am. Chem. Sac* 51 1485 (1929) 46* Whitmore and Williams J. Am. Chem* Son* 55 408 (1955) H. Masson Compt. rend* 132 483 (1901) Mttset Chem* Sent* 78 1313 (1907) JX. Henry Compt. rend* 145 103 (1906) Braun Sobeeki Ber* 44 1927 (1911) 47* Glark Am. Chem* Soc. 33 529 (1911) 40* Clark J* Am* Chem. Boo. 50 I150 (1908) J* Bio* Chem,► 81 405 (1951) J* Am. Chem* Soc* 51 588 (1909) Levene — Marker 49* Clark 162—4 Dupont Compt. read. Grignard Chem* Zent, 72 II Konoi?alo« Chem* Zent. 73 Dupont Compt. rend* 152 156 I (1915) 625 (1901) 1271 (1902) 198 (1911) 50 50* Clark. £* Am* Chest* Boo* 51 „ Butlerov Ann. 9 U filImftn 5S* Morton aa4 Sam# 54* ghriner mil Fuson 65* French and Wertel gfeans 56* lalherbe 59 674 (1917) 189 55 (1877) 46 100 (1985) m 0140 (1956) Am* Chem*. Soe. J* Am* Chem* Soc* The Systematic Ide&ti.ficatian of Organic expounds *T* Am* Chem* Soe, 40 Qualitative Organic Analysis Ber* p* 62 1756 (1986) p. 184 50 519 (1919)