FQAM $PRAY~DREED CQTTAGE CHEESE WHEY AS A SOURCE OF SQLEDS EN SHEREEE Thesis {or flu Dogma of M. S. hiZCHlGM S’FATE WHEELS??? Lee E. Blakely 1964 THESIS LIBRARY Michigan State University ABSTRACT FOAM SPRAY-DRIED COTTAGE CHEESE WHEY AS A SOURCE OF SOLIDS IN SHERBETS by Lee E. Blakely Dry whey solids obtained by foam Spray drying fresh concentrated cottage cheese whey or whey which had been cultured with Lactobacillus bulgarigus or Streptococcus thermophilis were used to replace 25, 50, 75, and 94.5 per cent of the serum solids in orange, lemon and raSp- berry sherbet. Substitution of plain cottage cheese whey powder at all levels uniformly gave a fine quality sherbet with no flavor criti- cism. If all of the serum solids were replaced by cultured cottage cheese whey the sherbets were judged as "slight fermented". Sherbets made with whey solids added prior to pasteurization were judged good and possessed smooth body and texture. Addition of whey solids to the sherbet mix after pasteurization produced a slightly smoother sherbet. The amount of citric acid required to lower the pH of orange, lemon and raSpberry sherbet to 3.7 was reduced approximately 32, 50 and 26 per cent resPectively in sherbet with 94.5 per cent replacement of serum solids by dry acid whey. The bacteriological quality of whey powders and sherbets containing whey was excellent. FOAM SPRAY-DRIED COTTAGE CHEESE WHEY AS A SOURCE OF SOLIDS IN SHERBETS BY Lee E. Blakely A THESIS Submitted to the College of Agriculture Michigan State University of Agriculture and Applied Science in partial fulfillment of the requirements for the degree of MASTER OF SCIENCE Department of Food Science 1964 E32‘3€?0:T spar/H ACKNOWEEDGEMENT My sincerest thanks are extended to Dr. C. M. Stine for his counsel and guidance in initiating this study and in the prepara- tion of this manuscript. Appreciation is also extended to Dr. L. G. Harmon and Robert L. Bradley for reviewing this dissertation. ii TABLE OF CONTENTS Page INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 REVIEW OF LITERATURE . . . . . . . . . . . . . . . . . . . . . . . 2 Whey d13posal . . . . . . . . . . . . . . . . . . . . . . . . 3 Whey utilization . . . . . . . . . . . . . . . . . . . . . . 3 Sherbet formulation . . . . . . . . . . . . . . . . . . . . . 9 EXPERIMENTAL PROCEDURE . . . . . . . . . . . . . . . . . . . . . . 12 Condensing . . . . . . . . . . . . . . . . . . . . . . . . . 12 Production of a cultured high-acid whey . . . . . . . . . . . 12 Drying . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 Pasteurization and homogenization . . . . . . . . . . . . . . 13 Freezing . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Sherbet formulation . . . . . . . . . . . . . . . . . . . . . l4 ANALYTICAL PROCEDURES . . . . . . . . . . . . . . . . . . . . . . 16 Total solids determination . . . . . . . . .,. . . . . . . . 16 pH measurement . . . . . . . . . . . . . . . . . . . . . . . 16 Determination of titratable acidity . . . . . . . . . . . . . 17 Bulk denSity . . . . . . . . . . . . . . . . . . . . . . . . l7 Organoleptic evaluation . . . . . . . . . . . . . . . . . . . l7 Microbiological determinations . . . . . . . . . . . . . . . 17 RESULTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 DISCUSSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 SUMMARY AND CONCLUSION . . . . . . . . . . . . . . . . . . . . . . 38 APPENDIX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 B IBLIm WHY O O O O O O O O O O O O O O O O O O O O O 0 O O O O O 4 3 iii TABLES Page 1. General sherbet formula used in all trials. . . . . . . . , , 14 2. Sherbet formula with 94.5 per cent of the serum solids substituted with whey solids. . . . .‘. . . . . . . . . . . . 15 3. Properties of orange, lemon and rasterry sherbet prepared with various amounts of foam Spray-dried cottage Cheese whey and adjusted to a pH of 3.7 with citric acid after addition Of flavor. o o o o o o o o o o o o o o o o o o o o o 20 4. Properties of orange, lemon and rasterry sherbet prepared with various amounts of foam Spray-dried cottage cheese whey cultured with L, bulgaricus. . . . . . . . . . . . . . . 21 5. Properties of orange sherbet prepared with various amounts of foam Spray-dried cottage cheese whey cultured with g. thermOEhiliS. O O I O O O O O O O O O O O O O O O O O O I 22 6. The average reduction in quantity of citric acid needed to lower the pH of some sherbets to 3.7. . . . . . . . . . . . . 23 7. Effect of whey solids added after pasteurization on the observed tactual property in sherbets and their respective mixes O O O O O O O O O I O O O O O O O O O O O O O O O O O O 28 8. Effect of whey solids added prior to pasteurization on the observed tactual property in sherbets and their reSpective mixes. 0 O O O I O O O O O O O O O O O O I O C O O O O O O O 28 9. Bacteriological quality of various whey powders after two weeks Storage. 0 O I O O O O O O O O O O O O O O O O O O O O 29 10. Bacteriological quality of sherbets prepared with various amounts of foam Spray-dried cottage cheese whey added prior to and £0110W1ng pasteurization. o o o o o o o o o o o o o o 30 1a. Some properties of plain cottage cheese whey no. 6. . . . . . 40 2a. Some properties of cottage cheese whey no. 2 cultured with L. bUIgari-cus. O O O O O O O O O O O O O O O O O O O O O O O 40 3a. Some properties of cottage cheese whey no. 8 cultured with E. bulgaricus. O O O I O O O O O O O O O O O O O O O O 0 O O 41 4a. Some properties of cottage cheese whey no. 4 cultured with g. themmhili-SO O O O O O O O O O O 0 I O C O O O O O O I O 41 5a. Some properties of plain cottage cheese whey no. 5. . . . . . 42 iv INTRODUCTION Increasing annual production of cottage cheese has resulted in economic and public health problems associated with whey disposal. Due to the low pH of cottage cheese whey and the distinct odors and flavors produced by lactic fermentations, the usesfor cottage cheese whey are much more limited than is the case for sweet cheese whey. Fluid cottage cheese whey has been used in the manufacture of sherbets. However, the inconvenience of handling liquid whey in many plants and the great difficulty encountered in conventional spray drying of cottage cheese whey has restricted the utilization of whey in sherbets. The relative ease with which cottage cheese whey can be foam Spray-dried suggested that such whey powders might be readily substituted for serum solids in the manufacture of sherbet. The purpose of this research was to determine whether foam spray-dried cottage cheese whey could be used as a source of serum solids in fruit flavored sherbet. If replacement of acidic whey solids for serum solids was feasible from the standpoint of ease of incorporation and quality of the frozen sherbet, then manufacturers could realize economic return from such usage and also make use of a presently wasted food ingredient. REVIEW OF LITERATURE In 1962 the United States Department of Agriculture (48) reported that 589 million pounds of cottage cheese curd were produced from approximately 3,680 million pounds of skimmilk equivalent. From the production of this cheese curd more than three billion pounds of whey were left for use or disposal. If the average total solids of this fluid whey was 6.62 per cent as indicated by Webb and Hufnagel (52), 204 million pounds of whey solids could be manufactured from this whey. From the data of Stine and Sargent (40) on composition of spray dried cottage cheese whey, one can calculate that 204 million pounds of whey solids would yield 24 million pounds of very high quality protein, possibly 2 million pounds of fat, 130 million pounds of lactose and 17 million pounds of lactic acid. Utiliza- tion of these presently wasted nutrients in foodstuffs is a matter of worthy consideration in view of our world population explosion. Increasing annual production of cottage cheese has also re- sulted in economic and public health problems associated with whey disposal. Many means of disposal and utilization of sweet whey have been developed; however, the uses and disposal of acid whey from cottage cheese are more limited because of low pH, odor and flavor. Whey Disposal The discharge of any industrial waste usually creates a diSposal problem. Dairy wastes are particularly troublesomein this respect. The large amount of organic matter in whey makes costly the disposal in sewage systems. Dumping whey into streams is unlawful in some states and may soon be in others because of the high biological oxi- dation demand of such wastes and consequent pollution of the stream. In a review of methods of treatment and disposal of dairy wastes Southgate (39) suggests that biological filtration or the activated sludge process are the best means of waste diaposal. In areas where conditions permit, irrigation is a method of disposal of whey. McDowall and Thomas (24) indicated that one acre of pasture land can accept at least 5,000 gallonsof undiluted whey, provided there is a period of about 14 days between dosings. Sharrett et a1. (37) showed that when properly applied, whey could increase the fertility of the soil; however, this method of utilization is limited by the fact that whey production is fairly concentrated in certain regions and land for disposal of the whey may not be available. This method of whey dis- posal also causes odor problems unless the process is carefully adminis- tered. Whey Utilization Feeding whey to livestock was one of the earliest means of whey utilization. Raw liquid whey was used for pig and calf feed if the stock were kept near the cheese factory. Since the livestock were often remotely located from the cheese factory, condensed and dried whey became the more practical product to ship or feed. Condensed whey of 35-50% solids was found by Tufft(43) to be an excellent chicken feed. Condensed as well as dried whey is useful in feeding chickens because of the effects of lactOSe in preventing coccidiosis and the beneficial effects of riboflavin and other nutrients on the growth of chicks. Becker et al.(11) successfully used dried whey as an ingredient in pig feed. Danielson et a1. (14) used a mixture of dried skimmilk and dried whey in pig starter rations. An excess of whey in the pig's diet was found to have a laxative effect. Many methods have been suggested for converting whey into a feedstuff suitable for ruminants. High-nitrogen feeds from whey have been developed by Arnott et a1. (8) and Czarnetzky (12) for feeding cattle. However, Hazzard et al. (21) found that dairy cows fed high-nitrogen feeds often had lower milk and butterfat production than cows on control diets. Although raw, concentrated or dried whey is a useful livestock food supplement, the use of whey for this purpose is limited because of cost and nutritional considerations. Using whey solids in the manufacture of food products for human consumption is more efficient, from the human nutritional standpoint, than feeding whey solids to animals and then consuming the animals as food to gain the nutrients present in the whey. There are many ways in which whey, either plain or modified, can be used in food products. The utilization of whey in food and non-food products is reviewed by Webb and Whittier (54, 55) and Wix and Woodbine (56, 57). The chemical and physical properties, as well as the flavors of food, in many instances are claimed to be improved by the addition of whey solids. Webb and Whittier 1(55) report that one of the largest outlets for whey solids is in the production of proc- ess cheese foods, where plain condensed or dried whey solids are added to the emulsified cheese mixture. Badad et a1. (9) used whey protein in process cheese food production. Ziemba (60) reported on the pro- duction of a free-flowing stabilized whey powder that gives soft body characteristics to cheese foods and spreads. A whey cheese popular in Scandinavia is called Mysost or Primost (50). "Albumin" cheese, commonly known as Ricotta or Ziger, is made by precipitating the proteins of whey in the presence of acid at elevated temperatures. The baking industry is the largest single potential user of whey solids (4). iMuch work has been reported on the use of whey solids in ' all types of bakery products (1, 4, 18, 22, 32, 60). Whey solids are used in bread, rolls, fermented sweet products, cakes and other baked goods. The lactose promotes desirable browning, while the heat- coagulable proteins contribute to structure during baking. Cakes, cookies and doughnuts are more tender and keep their softness longer if whey is included in the mix. Whey also has been used successfully in confections (l, 6, 51). Webb and Whittier (55) formulated a whey fudge which contained 43 per cent sweetened condensed whey. The sweetened condensed whey used in the fudge formulation was manufactured according to the method of Ramsdell and Webb (29). This method consists of condensing a mixture of fresh whey and sugar. Processing whey in this manner preserves the whey in a form directly usable in sweet foods. Whey proteins help provide emulsion stability in soups and soups containing whey solids are more natural in color than soups made with milk solids (53). Since there are only small amounts of casein present in whey, the use of whey solids in acid fruits, fruit juices and soups is advantageous to reduce curd formation which normally would occur during processing if milk solids were used. Ramsdell and Webb (30) found that as muCh as 25% of the total solids of spray-dried soups could be substituted with whey without the development of a whey flavor. Whey protein has foaming properties which can be compared to those of egg albumin and Ramsdell and webb (29) suggested that modified whey can be whipped for use in food preparations.. However, whey pro- tein cannot be used in products in which air must be incorporated by whipping and a firm structure set up by heat coagulation. Rogers et al. (31) modified cheese whey and spray-dried sweet whey to produce an edible foaming and aerating agent having many of the properties of egg albumin, gelatin and soya derivatives. Numerous other uses for whey solids have been developed. Whey has been incorporated in products such as instant potatoes, salad dressings, starch puddings, sauces, dips and comminuted meat products. Detailed information about some of these uses for whey are to be found in the text by Whittier and Webb (59). The components of whey have been modified, allowing whey solids to be used in a greater variety of products. The fat can by hydrolyzed with lipases, the lactose fermented, proteins modified or minerals re- moved (7). Whey can be blended with milk to produce a mixture which has beneficial properties of both the milk and the whey. Barnes et a1. 1(10) produced an edible high-acid powder by blending cultured condensed cottage cheese whey with skimmilk and spray drying the blend. By de- mineralizing whey, an infant food has been made which has a composition close to that of human milk. Stribley (41) reports that by using electro- dialysis, the salt content of whey can be reduced to a level whereby whey can be used in the manufacture of special baby food formulas which closely resemble the composition of.human.milk. The major constituent of whey is lactose. Lactose has been used in infant foods, pharmaceuticals, the production of lactic acid, ribo- flavin and ethyl alcohol. Lactose also has many non-food uses. In an extensive review Whittier (58) discusses the production and utilization of lactose. Usage of sweet whey in foods has grown rapidly since 1954 when U. S. Extra Grade Dry Whey was defined in the Federal Register (45). These standards on flavor, color, sediment, moisture, acidity and bacterial count assure that U. S. Extra Grade Dry Whey will be of uniform high quality. Dry sweet whey has been used in ice cream since World war II. ‘Many state standards now allow whey in one form or another to be added to ice cream and/or sherbet. Federal definitions and standards published in October, 1963 do not include whey as an optional ingredient in ice cream, but the definitions do include whey as an optional ingredient in sherbet (49). Nielsen (27) indicated that the most commonly used level of whey solids in ice cream is 20 per cent of the serum solids. Whey at this level gives satisfactory body and texture characteristics to ice cream. Leighton (23) showed that 19 to 65 per cent of the serum solids of ice cream can be added as whey solids without the danger of sandiness. The percentage serum solids that can be replaced with whey depends upon the fat and serum solids content of the mix. Rosenberger and Nielsen (33) summarized the advantages for using spray-dried whey pow- der in ice cream as follows; (a) Cost --- whey solids are cheaper than other common serum solids; (b) Improvement in the whipping ability; (c) DiSpersibility; (d) Good body and texture and a slower melt-down. The chief disadvantage of using whey powder is that the flavor of ice cream may be slightly inferior to ice cream made from fresh cream and concentrated skimmilk. Good quality sherbets can be made by using whey solids in place of the milk solids normally used in sherbet manufacture (5). Gholson et al. (17) indicated that pineapple, orange and raspberry sherbets, in which as much as 90 per cent of the serum solids was replaced with whey solids were very desirable in all respects. Potter and Williams (28) made an extensive study on the use of whey in sherbets. Sherbets were made from fresh fluid whey obtained from the manufacture of cheddar, swiss and cottage cheese. Condensed, sweetened condensed and dried whey were also used to make sherbets. The addition of whey to sherbet greatly improved whipping ability. Excessive overrun, caused by the addition of whey to sherbet, could be avoided by adding 0.6 to 2 per cent fat to the sherbet mix. Homogenization reduced the ability of the added fat to retard whipping. The non-heat-coagulable protein fraction of whey was found to be responsible for the unusual whipping properties of whey sherbets. Potter and Williams (28) found that citric acid was not necessary to acidify sherbet mix when cottage cheese whey replaced the milk solids normally used.‘ Savings in citric acid approximating 10 cents per 100 pounds of sherbet base could be realized if cottage cheese whey was used as a source of solids. No whey flavor was carried over to the finished product when a good quality whey was used. Since most of the acid coagulable casein is not present in whey, sherbet contain- ing whey solids showed no tendency to curdle. Potter and Williams (28) used fluid cottage cheese whey in sherbet manufacture. Fluid whey is inconvenient and unecondmical to handle, ship or store. Powder made from cottage cheese whey because of its hygroscopicity, tends to clump and "ball" in conventional Spray drying equipment and is difficult to handle in pneumatic conveyors. Foam spray drying as developed by Hanrahan and Webb (19) produces a powder which is easily and economically handled. The relative ease of pro- ducing and handling foam spray-dried whey makes the use of dried acid whey in sherbet manufacture attractive. Sherbet Formulation The choice of sherbet formula will depend upon individual 10 preferences for sweetness, texture and body, milk solids content and acidity. A good sherbet should contain about 25 to 35 per cent carbo- hydrate according to Frandsen and Arbuckle (16). By replacing 20 to 25 per cent (w/w) of the sucrose with dextrbse, Dahlberg (13) indicates that surface crystallization of sucrose is prevented. As demonstrated by Ross (36) a sherbet with the correct amount of sweetness and total sugar content can be made using 20 per cent cane sugar and 8 per cent corn syrup solids. Ross (34) stated that as the percentage of sugar used in the formula is increased, body and texture improve, flavor becomes more distinct and the acid gives a sharper flavor to the sherbet. Federal regulations now require that sherbets contain milk solids (49). These solids contribute desirable properties to sherbets. Day et al. (15) suggested that the level of total milk solids should be about 4 to 5 per cent (w/w) of the sherbet formula. Solids~not-fat improve body and texture and tend to prevent a weak body and coarse texture (35). Too high a milk solids-not-fat (MSNF) content reduces the intensity of fruit flavor and is therefore usually limited to 3 per cent or less. The usual fat content of sherbet is in the range of l to 2 per cent. When the MSNF content of a sherbet is held constant the rich flavor increases directly with increasing fat content. Stabilizers are important in sherbets to improve shelf life and control overrun. There are many sherbet stabilizers available, such as the vegetable gums, pectins and propylene glycol alginate. The 11 choice of stabilizer and amount to use depends on overrun desired and the body and melt-down characteristics sought by the manufacturer (44). The amount of fruit that must be contained in sherbets now is under Federal regulation (49). For a fine fruit flavored sherbet only the best fruit juice or puree should be used, possibly in conjunction with a pure flavor essence. One of the most important considerations in the production of sherbet is acidity. Unless the acidity of each batch is carefully controlled the fruit flavor will not be at an optimum. The desired acidity is dependent upon the type of fruit sherbet made. Day et a1. (15) suggested that the most desirable acidity in a sherbet is 0.55 to 0.60%, expressed as citric acid. Frandsen and Arbuckle (16) recommended that the titratable acidity of sherbet should be 0.35 to 0.52 per cent, expressed as lactic acid. Preferably the acidity should be 0.47 to 0.52 per cent or in a pH range of 3.6 to 3.8. Each batch of sherbet should be titrated for acidity just prior to the addition of citric acid and then standardized to the desired acidity or pH. Shortledge (38) advised that pastel shades in foods are the most appetizing. The color of a sherbet should not be darker than the color of the base fruit. The percentage of overrun that is presently acceptable in most consumer markets is 35 to 45 per cent (16). Color, pH and overrun are characteristics which vary widely according to the area in which the sherbet is manufactured and sold. EXPERIMENTAL PROCEDURE The purpose of this research was to determine if foam spray- dried cottage cheese whey could be effectively used as a source of serum solids in sherbets. Once the feasibility of using such whey was established the remaining trials were directed toward ascertain- ing the maximum replacement of normal serum solids consistent with good flavor, body and texture. When acid whey is added to sherbet mix there is a reduction in the quantity of citric acid needed to lower the pH of the mix to the desired level. In all trials the amount of citric acid needed to bring the pH of the base mix to 3.7 was determined. Condensing: Fresh cottage cheese whey was obtained from the Michigan State University dairy plant and filtered through a single gauze faced 6 1/2 inch Rapid-Flo filter disk to remove small pieces of curd which were present in the whey. The whey was preheated to 115 F, con- centrated in a 16 inch Rogers vacuum pan to 40-50 per cent total solids and immediately foam spray-dried. Production of a Cultured HightAcid Whey; Several batches of whey were cultured before concentration to ascertain whether any additional acid- ity or other fermentation products might have beneficial effects on the flavor of sherbets to which such whey was added. Fifty gallon lots of fresh cottage cheese whey were inoculated with a 1 per cent inoculum of either Lactobacillus bulgaricus or Streptococcus thermophilis 12 13 and incubated at 45 or 37 C, respectively, for 24 hours. Drying}! The cottage cheese whey concentrate was foam spray-dried using the nitrogen injection technique described by Hanrahan and Webb (19). A Rogers co-current horizontal inverted tear-drop dryer equipped with a Spraying Systems type SEC 6 nozzle with a 0.040 inch orifice diameter was used for drying. Atomization pressure was 1000 lbs./sq. in. with nitrogen injected under a pressure of 1050 1bs./sq. in. at a rate of 2.0 cubic ft./gal. as the concentrate left the high pressure pump. Inlet air and exit air temperature averaged 260 F and 185 F, respectively, during spray drying. The powder was collected and stored in polyethylene bags. Pasteurization and Homogenization:‘ The pH of sherbet mixes containing whey solids is markedly lower than the pH of mixes containing serum solids which are normally used in sherbet manufacture. Since the pH of mixes containing whey was low, trials were run to determine if this lower pH would cause coagulation or precipitation and preclude the pasteurization temperature normally used on such products. Mixes were made containing only the following basic ingredients: cream, sucrose,corn syrup solids, stabilizer and water. These mixes were heated to 165 F,held for 30 minutes, subjected to two stage homogenization at 2500 psi and immediately cooled to 33 F using a surface cooler. Other mixes were made which included whey and/or nonfat dry milk (NDM) as one of the basic ingredients. These mixes 14 were pasteurized at 150 F or 160 F for 30 minutes or flashed at 175 F, followed by homogenization and cooling. The cooled mixes were then aged at 34 F for 24 hours before freezing. Freezing: Additional serum solids, if needed, fruit juice, flavor, color and citric acid were added to the sherbet mix. The sherbet mixes were frozen in an Emery Thompson 2 1/2 gallon batch freezer to approximately 45 per cent overrun and hardened at -25 F in moving air. The frozen samples were transferred to a freezer cabinet at 2 to 5 F for observation of body and texture Changes. Sherbet Formulation: The formula used in making sherbets was 20% sucrose, 8% corn syrup solids, 0.5% stabilizer, 1.5% fat and 3.5% serum solids. Table 1 indicates the general formula used in.making the sherbets employed in all trials. Orange, lemon and raspberry TABLE 1. Sherbet formula used in all trials. Amount used (lbs) 'Ingredients 20.0 sucrose 8.0 frodex (42% dextrose equiv.) 3.8 cream (40% cream) 3.4 N114 (3.2% moisture) 0.5 stabilizer 64.3 combined weight of water, fruit etc. sherbets were made. The optimum amount of fruit, flavor and color to add was determined in advance and this amount was used in all subse- quent trials. In preparing ten pound batches of orange sherbet mix, 254.2 g of pure 4:1 frozen orange juice concentrate, 9.9 g of natural 15 orange and 2.8 g of orange color were added prior to freezing. When lemon sherbet mixes were made, 170.2 g of frozen lemon juice, 8.7 g of natural lemon flavor and 2.7 g of yellow color were added. Just prior to freezing raspberry sherbet mixes,‘ 300 grams of fresh frozen raspberry puree and 4.5 grams of natural raspberry flavor were added. In all cases commercial 50% citric acid solution was used to adjust the pH of the mix to 3.7 or 3.5. Foam spray-dried cottage cheese whey was substituted at various levels for the NDM normally used in preparing sherbet mixes. The per- centage of the total serum solids that was replaced with whey solids was considered the level of substitution. Therefore, 100 per cent substitution of the serum solids with whey solids could not be accom- plished since the cream contributes approximately 5.5 per cent of the total serum solids. Table 2 illustrates the formula of a sherbet mix which has essentially all of the serum solids substituted with whey solids. TABLE 2. Sherbet formula with 94.5 per cent of the serum solids sub- stituted with whey solids (10 lb. batch). Amount used (lbs) Ingredients 2.0 sucrose 0.8 frodex (42% dextrose equiv.) 0.38 cream (40% cream) 0.34 whey solids (3% moisture) 0.05 stabilizer 6.43 combined weight of water, fruit, etc. Some of the sherbet mixes were prepared with the serum solids, in the form of dry whey and/or NDM, added after pasteruization and cooling. 16 The milk and/or whey solids were incorporated before the addition of the fruit, flavor, color and citric acid. Other sherbet mixes were prepared in such a manner that whey and/or NDM was added prior to pasteurization. Comparisons were made between sherbets prepared with whey solids incorporated into the mix either prior to or following pasteurization. ANALYTICAL PROCEDURES Total Solids Determination: To determine the total solids of liquid whey, condensed whey and sherbet the Mojonnier procedure was followed (26). Total solids on NDM or whey powder were determined by the Cenco Moisture Balance Method (26). pH Measurements: pH determinations were made on liquid whey, condensed whey and reconstituted whey powder. When preparing sherbet mixes, pH readings were taken both prior to and following serum solids addition and after the addition of fruit juice, flavor and color. A pH meter was also used to indicate when the correct amount of citric acid had been added to attain the desired pH in the sherbet mix. Since the sherbet mixes just prior to freezing had relatively low temperatures a buffer solution of known concentration and at the temperature of the mix was used to standardize the pH meter. pH measurements were made with a Beckman Zeromatic pH meter using a calomel half cell and a glass electrode. 17 Determination of Titratable Acidity: The acidity of fluid and concen- trated whey was found according to the procedure outlined by the Milk Industry Foundation (26). Whey powder acidity was obtained using the method recommended by the American Dry Milk Institute (2). The titratable acidities of frozen sherbets, expressed as citric acid, were determined on fluid sherbets following equilibration at room temperature. After miXing, a 9 gram sample was weighed and titrated to a pH of 8.4 (phenolphthalein endpoint), using the pH meter to indi- cate the endpoint. Bulk Density: The bulk density of a powder was determined by weighing an empty 100 ml. graduated cylinder, filling with powder to the mark, tapping the cylinder at intervals to settle powder, weighing the cyl- inder plus powder and Calculating the bulk density as g/ml. (20). Organoleptic Evaluation: The flavor, body and texture evaluations of the sherbets were made by experienced judges. All samples were coded, individually criticized and placed according to their relative prefer- ence compared to other samples. Microbiological Determinations: In several experiments the serum solids or whey solids were added after pasteurization. Since the finished sherbet would then contain dairy ingredients which technically had not been pasteurized during mix processing, the assessment of microbial populations seemed desirable. Standard plate counts for total and coliform organisms were made to determine the bacteriological quality of both whey powders and the finished sherbets(3, 26). RESULTS The fresh cottage cheese whey collected for processing had a total solids content of 6 to 7 per cent; immediately following con- centration to 25 to 55 per cent total solids, the whey was foam spray- dried. Analyses were made to determine the pH, total solids and titratable acidity of the fresh whey and concentrate used in pro- ducing the various foam Spray-dried powders. Titratable acidity, moisture and bulk density were determined on the whey powders used in preparing sherbet mixes (Appendix la - 5a). The resulting powders had low bulk densities and moisture contents, were free flowing and readily soluble in the mixes to which they were added. Foam spray- dried cottage cheese whey is hygroscopic unless crystallization techniques are employed, and must be packaged and stored to avoid moisture absorption. The titratable acidity of cottage cheese whey obtained from the cheese vat was 0.45 to 0.53 per cent, expressed as lactic acid. Culturing whey with L, bulgarigus or S, thermophilis raised the acidity of the whey, thus enabling production of high acid powders. When L, bulgaricus was used to culture whey the acidity was raised to 0.70 to 0.96 per cent and the corresponding whey powders made from such whey had acidities of 11.86 to 12.50 per cent on a dry basis. Plain foam Spray-dried cottage cheese whey powders had acidities of 5.93 to 6.68 per cent. When whey was cultured with S. thermophilis the titratable acidity increased only slightly over that observed in the original whey. Powder made by foam Spray drying whey cultured 18 19 with S, thermophilis-had a titratable acidity of 7.00 per cent. In preparing sherbets wherein whey was substituted for the serum solids normally used, individual batches of mix were processed. These mixes were designed so that 25, 50, 75 or 94.5 per cent of their serum solids were replaced by foam spray-dried plain or cultured cottage cheese whey. A control containing NDM as the only concen- trated source of serum solids was included in every group. The pH of mixes with added serum solids was observed and recorded before the addition of fruit and flavor. The pH of the base mix, before addition of fruit juice and flavor, decreased as the content of dried cottage cheese whey increased (Tables 3 to 5). The extent to which the pH of the mix is lowered is also dependent upon the acidity of the whey powder employed. The lower pH of the base mixes containing whey results in a reduction of the quantity of citric acid needed to lower the pH of the sherbet to the desired level. The data contained in Table 6 illustrate average reductions in the quantity of citric acid needed to lower the pH of orange, lemon and raspberry sherbets to 3.7. The greatest reduction in the quantity of citric acid required was noted in lemon sherbets, followed by orange and raspberry. In some orange, lemon and raspberry sherbets, reductions in the quantity of citric acid required were as high as 42, 54 and 30 per cent respectively. When sherbets were adjusted to a lower final pH of 3.5 more citric acid was required than sherbets adjusted to 3.7. Orange sherbets 20 .mm oHan qxaoaommm uasmcoo Hogan menu a“ vow: .mH oHan «awesommm uaomcoo Hmfiuu menu ca com: has? no sumo mom a moss do sumo mom a omnmoo .Hm snooam poow ooow om.m mH.m 0H.n m.qm omuooo .Hm nuooam ooom ooow oo.m mm.m oq.m mm omuooo .Hm nuooam ooom ooow Nm.m mo.m om.m om omuooo .Hm nuooam ooow ooom om.o oa.o mm.o mm omumoo .Hm smooam ooow voow om.m mo.w om.o o when om ammo 0 what on memo o nmuuoommmm maoaog mowcmuo Anson Homv mofiHom hose on eunuxou um uo>wam Anew sows moHHOm one moon HoHoo abuse mo no Ho>mHm mo cowusuwumASm m m ou N um wououm monumnm mo huwaono aowuaooo mnemon xwa cameo mo aoHuomom .uo>mHm «0 cowufloom Houmm oHoo oauuwo Suez m.m mo mm m on ooumnnom one more omooso ammuuoo ooauoumoumm Boom mo muzsoao msoauo> sues ooummon noouosm headphone one :oaoH «owamuo mo mowuuomoum .m mnmmHm mo aowufiwow man knows vwom owuuflo Sofia m.m ou woumsnom muonuonm muuonammu one zoama no mm m omumoo .Hm nuooEm onoow ovoow om.q wH.¢ o~.q m.am omumoo .Hm nuooam ooow ooow mm.q mm.q om.¢ mm omuwoo .Hm spooam voow ooow om.m oo.m mo.¢ om omumoo .Hm nuooam ooow poow om.o mm.m om.m mm omumoo .Hw :uooam coow ooom om.o ow.o oaeo o ammo co ammo 0 when oo whom o omuuonmmom nsoamn.lmwwnmuo Auaoo Homv moHHom hogs um manuxou um Ho>mHm Ammv sows moHHOm mvflfl hfiom NHOHOO Shmm HO HO Ho>mHm mo dowusufiumosm m m on N um wououm workman mo huaamno dowufioom ouowmo xwa demon mo coauomom E .mmmmwmwasn em nufis omnnuaso moss choose owmuuoo ooauou%wumm Boom mo muqsoam mnowuop sues venomonm monuosm huuonmmmu one coaoa aowamuo mo mowuuomoum .q mum